Written by Gary Korb
Tuesday, March 02 2010
A few weeks ago I posted a video on how to setup and season a new
humidor. The humidor was a
Bally IV glass top model; a decent affordably-priced
box. Since I recorded that video, the humidor has been keeping a consistent 68% RH and the cigars are in good shape.
During the video I commented that because the humidor had a glass top, the humidifier had to be placed on the bottom, rather than under the lid, which brings us to today's subject.
The stock humidifier for this humidor is a standard, large, rectangular green foam model. It sits in a block of Spanish
cedar that has vents cut into both sides to allow the moist air to escape. (Note that the humidifier is only vented on
one side.) The block is made to fit firmly between the front and back walls. You can place the humidifier anywhere along the bottom, but the logical place seems to be flush against either the right or left wall with the open side of the humidifier facing out towards the cigars. Put in the
cigars, forget about it, and see you later. So far so good, right? (
See above photo) What's wrong with that picture?
This brings us to the crux of this story which was due to either an oversight on my part, or to an oversight by the manufacturer. (The humidor comes with no set-up instructions.)
A few days ago it was time to check the humidifier. It was still pretty damp so I left it alone.
While I was in there, I decided to move a few cigars around. That's when I discovered the inconvenient truth. A rare La Gloria Cubana Reserva
Figurado which had been touching the housing was wet and swollen. The cigar above it, a
Davidoff Special R was a little better, but very soft. This was totally unacceptable.
Once the sinkin
g feeling in my gut subsided, the only solution I could think of was to
reverse the position of the humidifier and point it towards the wall. But that presented the problem of getting the air to circulate. Therefore, the housing would have to be moved
away from the wall to permit proper all flow. (
See the open space in the non-shaded area at left.)It cost me some space, but it seems this is the only logical way to place the humidifier in this type of situation without ruining your cigars.
What I want to know is, has anyone else found themselves in a similar situation and how did you deal with it?
~Gary Korb
Click the link to see the video on
how to season a new cigar humidor.
